Product ID:WHITE BOX SAVER 7091
MSDS Date:02/27/1986
FSC:6850
NIIN:00N009335
MSDS Number: BCSDV

CROWN INDUSTRIAL PRODUCTS CO., INC.

STATE LINE ROAD
HEBRON, IL 60034

Emergency Phone: 815-648-2424

Info Phone: 815-648-2424

Preparer: ROBERT E. BAYTON

Cage: 92381

CROWN INDUSTRIAL PRODUCTS CO

350 HEBRON, IL 60034 US

Telephone: 815-648-2424

Cage: 92381

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 1-10%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

NAPHTHA (PETROLEUM SPIRITS OR BENZIN)

CAS: 8030-30-6

RTECS: SE7555000

Fraction By Weight: 1-10%

OSHA PEL 100 PPM

PROPYLENE GLYCOL MONOMETHYL ETHER ACETATE

CAS: 108-65-6

RTECS: AT8925000

Fraction By Weight: 1-10%

OSHA PEL OSHA PEL

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 11-30%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYLENE CHLORIDE (SARA III)

CAS: 75-09-2

RTECS: PA8050000

Fraction By Weight: 11-30%

OSHA PEL 500 PPM/C,1000; Z2

ACGIH TLV: 50 PPM, A2; 9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LIQUIFIED PETROLEUM GAS SWEETENED

CAS: 68476-86-8

Fraction By Weight: 11-30%

OSHA PEL OSHA PEL

ACGIH TLV: ACGIH TLV

Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS & SYMPTOMS OF OVEREXPOSURE.
Explanation of Carcinogenicity:ACGIH:SUSPECTED HUMAN CARCINOGEN
Effects of Overexposure:INHAL: HIGH VAPOR CONCENTRATION MAY RESULT IN
DIZZINESS HEADACHE OR UNCONSCIOUSNESS INGEST NOT LIKELY. EYE MAY
CAUSE IRRITATION.POSSIBLE CORNEAL INJURY,SKIN PROLONGED MAY CAUSE
DEFATTING OF SKIN,LEADI NG TO IRRITATION.PERMATITIS.NOT LIKELY TO
BE ABSORBED IN TOXIC AMOUNTS.
Medical Cond Aggravated by Exposure:MAY INCREASE MYOCARDIAL IRIT
ABILITY.AVOID EPINEPHRINE OR SIMILAR DRUGS IF AT ALL POSSIBLE

First Aid:CALL A PHYSICIAN EYES: FLUSH WITH H*20 FOR 15 MINUTES OR
UNTIL IRRITATION SUBSIDES.SKIN:REMOVE ALL CONTAM CLOTHING WASH WITH
SOAP & H*20.INHAL:REMOVE FROM EXPOSURE IMMEDIATELY.BREATHING IS
IRREGULAR O R STOPPED START ARTIFICIAL RESP & ADMINISTER 0*2.
INGEST DO NOT INDUCE VOMITING DRINK PLENTY OF H*20

Flash Point Method:TCC
Flash Point:(SEE SUP DATA)
Lower Limits:1.8
Upper Limits:9.5
Extinguishing Media:CARBON DIOXIDE DRY CHEMICAL,FOAM
Fire Fighting Procedures:WEAR PRESSURE DEMAND SCBA & FULL PROTECTIVE
EQUIPMENT
Unusual Fire/Explosion Hazard:TREAT AS CYLINDERS OF COMPRESSED GAS.
THERMAL DECOMPOSITION PRODUCTS MAY INCLUDE HCL & PHOSGENE

Spill Release Procedures:VENT.AREA REMOVE ALL SOURCES OF IGNITION CLEAN
UP WITH INERT MATERIALS & DISPOSE OF IN ACCORDANCE WITH ALL LOCAL
STATE & FEDERAL LAWS.

Handling and Storage Precautions:DO NOT STORE IN DIRECT SUNLIGHT,NEAR
OPEN FLAME OR TEMPERATURES EXCEEDING 120F.DO NOT SMOKE WHILE
SPRAYING.
Other Precautions:NO SMOKING IN AREA OF USE DO NOT USE IN GENERAL
VICINITY OF ARC WELDING OPEN FLAMES OR HOT SURFACES. HEAT &/OR UV
RADIATION MAY CAUSE THE FORMATION OF HCL &/OR PHOSGENE

Respiratory Protection:RESPIRATORY PROTECTION SHOULD BE IN ACCORDANCE
WITH 29 CFR 1910.134. NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN
Ventilation:LOCAL EXHAUST IS ADEQUATE.
Protective Gloves:POLYETHYLENE OR NEOPRENE
Eye Protection:CHEMICAL WORKERS GOGGLES )FP-N)
Other Protective Equipment:PROTECTIVE CLOTHING & EQUIPMENT.SEE 29 CFR
1910.132$133.
Work Hygienic Practices:OBSERVE GOOD WORK HYGIENIC PRACTICES
Supplemental Safety and Health
FL PT:AEROSOL CONTAINER <2O F- -6.67 C.

Vapor Pres:45-50PSIG
Vapor Density:>1
Spec Gravity:>1
pH:
Evaporation Rate & Reference:<1(ETHER=1)
Solubility in Water:NEG
Appearance and Odor:WHITE/ETHEREAL ODOR
Percent Volatiles by Volume:790
Corrosion Rate:

Stability Indicator/Materials to Avoid:YES
ALKALI METALS.MINERAL ACIDS.
Stability Condition to Avoid:OPEN FLAMES,SPARKS ELECTRICAL SPARK
SOURCES.
Hazardous Decomposition Products:HCL PHOSGENE

Waste Disposal Methods:AEROSOL CONTAINER:DO NOT PUNCTURE OR
INCINERATE.EMPTY CONTAINERS MAY BE DISPOSED OF THROUGH NORMAL
CHANNELS.FULL OR PARTIALLY FILLED CONTAINERS ARE CONSIDERED
HAZARDOUS WASTE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.